Libertyville, IL Sewer & Duct Repair

10-12-2026: took measurements in preparation for lining from open hole in back of house to patch near 6” clean out in front of house, also line from open stack in water heater closet to 4” main line, and epoxy coat from toilet collar to drop at 4” stack. 10-14-2026: lined sewer from open hole in back of house downstream 32’ to 6” pvc clean out in front of house, also lined from open stack in water heater closet 17’ downstream overlapping liner in 4” main run forming wye connection liner, reinstated back end for kitchen drain line also reinstated toilet line tie in on stack, epoxy coated from pulled toilet to tie in on stack line. Plumber Tom repiped 4” clean out in back of house along with 2” kitchen drain line that ties in just downstream of clean out.

Televised underground air ducts. Ducts are believed to be transite. An estimate to encapsulate will be provided. Televised two duct runs and found a 3rd duct run but not access. Believed to be tiled over the register but will be able to encapsulate that run as well.

9-2-2026: televised sewer from open hole in back of house downstream 14’ to blockage in line where previous plumbers rod left the pipe and caused sand/pea gravel backfill to enter pipe and block line just upstream and right at toilet/stack tie in, vacuumed all loose backfill out of line and able to camera all the way to 6” pvc clean out in front of house, 4” cast is split, cracked and very fragile throughout the entire line under house. Need to send estimate to line main 4” cast line from open hole to 6” pvc clean out in front , also line bathroom stack line over to main 4” line and possibly a connection liner at tee connection where stack line ties into main run. Floor drain downstairs was not draining rodded with c8 to clear line back to where it ties in near downstairs toilet.

7/01/26 applied first application of duct armor to all duct runs and register openings. 7/09/26 applied second application of duct armor to all duct runs and register openings

Cleaned and televised all underground ductwork in preparation for trenchless spincast mortar. Applied trenchless spincast mortar to all underground connections. Repaired register vents with hydraulic cement. 3-25-26 Installed 2 9” heavy gauge galvanized metal elbows in both areas where elbows were excavated. Applied hydraulic cement around both elbows and encapsulated both elbows with duct armor. Applied first application of duct armor to all underground duct work. 4/1/26. Applied 2nd application of Duct Armor to plenum and all registers and duct runs.

Televised and located three areas in the floor where customer will break up and expose the pipes in order to provide proper access to mortar and spray line.

Televised ducts under slab floor. Ducts are concrete with metal fittings that are extremely rusted. Will provide proposal for reaping metal and possibly spin cast mrtaring then spray lining remainder of concrete ducts.

Televised ducts under slab floor. Ducts are concrete with metal fittings. Metal fittings look in good condition Will provide quote for spray lining.

Televised ducts under slab floor. Ducts are concrete ducts possibly transite with metal fittings. Metal fittings look in good condition. Will provide a quote for spray lining to encapsulate concrete and also help for sealing for radon gas.

Estimate

Cleaned and measured sewer line. 4-27-2023: lined the sewer from a 6” pvc clean out in the front yard 40’ downstream to city main starting liner in 6” pvc just downstream of clean out and ending liner in 6” clay just before city main. Also lined the sewer from the same clean out 11’ upstream starting liner in 6” pvc just upstream of clean out and ending liner about 2’ into the 4” cast.

Televised sewer from outside clean out. Roots going downstream to main with some light cracks. Roots also at cast to clay. Suggest installing liner downstream and upstream to keep roots out in future.

Televised ducts under slab floor. Ducts are concrete ducts possibly Transite with metal fittings. Metal fitting on duct run coming from the front of the house are very rusted and should be spin cast mortared to restore the structure. After that the system should be spray lined with Duct Armor duct lining material.

Televised ducts under slab floor. Ducts are concrete ducts with metal fittings and connections that are very rusted allowing white ducts to enter the pipe. Suggest spin casting metal areas then spray lining ducts with Duct Armor duct lining material.

Televised ducts under slab floor. Ducts are pvc coated spiral wound metal ducts that are showing signs of rust and possible mold. Suggest solving issue with drainage then spin cast mortaring and spray lining ducts with Duct Armor duct lining material.

Televised ducts under slab floor. Ducts are plastic coated galvanized ducts showing signs of possible mold from ground water. Ducts are also showing signs of rust and calcification. Suggest fixing gutter and drainage issue then spin cast mortar the ducts and then spray line them with Duct Armor duct lining material.

We are cleaning all the underground duct work, applying our trenchless cast mortar to all underground duct work, which is a spiral wound metal duct with a PVC coating that flakes off allows mold growth and creates a fine white dust in the deterioration process, after it’s coated and restructured with the mortar we are applying two applications of our duct lining material to all the underground duct work!

We are applying the first application of our rubberized duct lining material to all of the heavily rusted underground metal duct work.

We are applying the first application of our rubberized duct lining material to all of the heavily rusted underground air ducts. The air ducts will be completely encapsulated and the air in the home will be safe for the customer to breathe.

We are applying the second application of our rubberized duct lining material to all of the heavily rusted underground duct work. The air ducts will be completely sealed and the customer will no longer experience dust and debris blowing out of their air vents.

We are applying the second application of our rubberized duct lining material to all of the underground asbestos transite air ducts. The air ducts will be completely sealed and the air in the home will be safe for the customer to breathe.

We are applying the second application of our rubberized duct lining material to all of the asbestos transite underground air ducts. The air ducts will be completely encapsulated and the air in the home will be safe to breathe.

We are cleaning all of the underground asbestos transite air ducts in preparation for our air duct lining process. Once all of the dust and debris is cleared from the system, we will apply two applications of our rubberized duct lining material. The air duct system will then be completely sealed and the air in the home will be safe for the customer to breathe.

We are cleaning all of the underground asbestos transite air ducts with our special high powered vacuum. Once all of the debris is cleared, we are going to apply the first of two applications of our rubberized duct lining material. The entire air duct system will be completely sealed and the air in the home will be safe for the customer to breathe.

We are applying our duct lining/sealing material to the underground duct work which in this case is transite pipe that may contain asbestos our product is being used to encapsulate the pipe leaving it environmentally safe.